P0441 on the Last Challenger Ever Built
Your 2023 Dodge Challenger — the final model year of this legendary muscle car — has flagged P0441 for incorrect EVAP purge flow. Whether you're holding one of the last HEMI V8s, a 392 Scat Pack, or the ultimate Hellcat, this isn't an engine issue. P0441 is an emissions vapor code that means the PCM detected abnormal purge flow from the charcoal canister to the intake manifold.
As a final-production collectible, getting this resolved properly through the dealer with full documentation is the smart move.
Symptoms You Might Notice
- Steady check engine light
- All horsepower and torque fully available
- No effect on transmission, performance modes, or launch control
- Possible faint fuel smell
Most Likely Causes
1. ESIM Defect
The ESIM near the charcoal canister is Stellantis's most common EVAP failure point. On a nearly new vehicle, a marginal factory unit is the leading suspect.
2. PCM Software Update
Final production year calibration refinements may be available. Stellantis may have released TSBs addressing EVAP monitor thresholds on the LD platform's last run.
3. Purge Solenoid Issue
A factory-defective purge solenoid that doesn't perform to spec under the extreme heat of the HEMI engine bay.
4. Assembly Connection
An EVAP hose or connector that has loosened after initial miles of driving.
What to Expect at the Dealer
- Drop off your Challenger — full warranty expected
- wiTECH 2.0 scan and TSB check
- Software update or component replacement
- Verification drive
Repair Cost Breakdown
- Under Stellantis warranty: $0
- ESIM (if out of warranty): $140 – $330
- Software update (if out of warranty): $100 – $175
- Purge solenoid (if out of warranty): $120 – $290
Can I Drive With P0441?
Yes. Your last-generation Challenger performs identically with P0441. Every bit of its power output is intact. No performance systems are affected.
DIY vs Professional
Take it to the dealer. Your 2023 Challenger is within Stellantis's 3-year/36,000-mile warranty, and EVAP qualifies for federal emissions warranty (8 years/80,000 miles). As a final-year collectible, dealer service records add provenance value.