Investigating P0441 on Your 2022 Hyundai Elantra
A P0441 code on your 2022 Hyundai Elantra means the ECM detected incorrect purge flow in the EVAP system. The 7th-generation Elantra offers a 2.0L four-cylinder, 1.6L turbo (N Line), or 2.0L turbo (Elantra N). There's also a hybrid variant with a 1.6L engine. P0441 targets the purge circuit — the PCSV (Purge Control Solenoid Valve) and vacuum lines routing fuel vapors to the engine.
How the Code Sets
The ECM opens the PCSV during steady driving and monitors fuel tank pressure. When flow deviates from calibration, P0441 stores. After 2–3 years, early component issues are possible but less common than on older vehicles.
Ranked Causes
- PCSV Failure (35% likelihood) — The Purge Control Solenoid Valve is the primary suspect. Part: $25–$70. Labor: $50–$105.
- Vacuum Line Issue (20% likelihood) — Cracked or loose hoses. Turbo models generate more heat. Repair: $10–$35. Labor: $25–$75.
- Canister Close Valve (CCV) (15% likelihood) — The vent-side valve affecting pressure dynamics. Part: $25–$75. Labor: $75–$155.
- Fuel Tank Pressure Sensor (10% likelihood) — Inaccurate readings. Part: $30–$80. Labor: $50–$100.
- Charcoal Canister (10% likelihood) — Saturation from overfilling. Part: $95–$250. Labor: $75–$155.
- Wiring/Connector (5% likelihood) — Corroded PCSV connector.
- Gas Cap Seal (5% likelihood) — If equipped with a traditional gas cap, check the seal. Replace: $8–$15.
Hybrid Note
If your Elantra is the hybrid model, the gas engine runs intermittently. EVAP purge monitors only activate when the engine is running, so code detection and clearing takes more drive cycles. Components are the same as the non-hybrid model.
Warranty Status
Your 2022 Elantra is likely still within Hyundai's 5-year/60,000-mile basic warranty. The 10-year/100,000-mile powertrain warranty (original owner) provides additional coverage. Check with your Hyundai dealer — repairs may be fully covered.
Repair Costs (If Out of Warranty)
PCSV: $75–$175. Vacuum lines: $35–$110. CCV: $100–$230. FTP sensor: $80–$180. Charcoal canister: $170–$405.